| ONE YEAR/6000 MILES (WHICHEVER COMES FIRST) |
| ENGINE OIL |
Replace |
| OIL FILTER |
Replace |
| COOLANT |
Inspect, top off using an approved coolant. |
| TRANSMISSION/FINAL DRIVE OIL |
Replace |
| SPARK PLUGS |
Inspect /replace |
| VALVES |
Inspect and adjust as required |
| CARBURETOR/THROTTLE BODY |
Synchronize as needed |
| IDLE SPEED |
Inspect - adjust |
| FUEL LINES |
Inspect lines and clamps; replace chafed lines, tighten clamps. |
| FUEL FILTER |
Inspect/replace as required |
| AIR FILTER |
Inspect/clean or replace as required |
| THROTTLE/THROTTLE CABLES |
Inspect and lubricate cables, check operation, adjust free play |
| CHOKE/FAST IDLE CONTROL |
Inspect operation. Lubricate and adjust linkage as needed |
| CLUTCH/CLUTCH CABLE |
Inspect cable adjustment. Lubricate cable and clutch lever pivot |
| STEERING HEAD BEARING ADJUSTMENT |
Inspect and adjust |
| SWING ARM AND LINKAGE |
Inspect and lubricate |
| FORK SEALS |
Inspect for leaks or other damage |
| REAR SHOCKS |
Inspect for leaks, worn bushings. |
| DRIVE CHAIN |
Inspect, lubricate, adjust |
| DRIVE BELT |
Inspect, check tension |
| DRIVE SHAFT |
Replace oil (if applicable) |
| BRAKE FLUID |
Verify level; if contaminated, replace. |
| BRAKE PADS |
Inspect/replace |
| BRAKE CALIPERS |
Wrench-check mounting hardware, check for leaks/chafed hoses or torn dust boots. Make sure all pistons are free. |
| BRAKE ROTORS |
Wrench-check mounting hardware, look for scoring or other damage |
| BRAKE MASTER CYLINDERS |
Inspect for leaks. |
| WHEELS |
Inspect and adjust spokes, Inspect wheel bearings for play. Inspect wheel seals for leakage. Inspect wheel alignment. |
| TIRE CONDITION AND PRESSURE |
Inspect and adjust. Replace worn or damaged tires. (Obviously, tires should be replaced whenever they're worn out, but they're often overlooked when the bike is infrequently ridden.) |
| ENGINE AND FRAME BOLTS |
Visual inspect and wrench check. Make certain all appropriate cotter pins/lock tabs are in place and bent over. |
| LIGHTS |
Inspect operation |
| BATTERY AND CHARGING SYSTEM |
Top off battery, check cable terminals, check charge rate. |